Interior Trim and Paneling.pdf
(
1057 KB
)
Pobierz
Document ID: 2095634
Page 1 of 3
2009 Chevrolet Aveo
|
Aveo, Wave, G3, Barina (VIN S/T) Service Manual
|
Body Hardware and Trim
|
Interior Trim and Paneling
|
Repair Instructions
|
Document ID: 2095634
Front Side Door Trim Panel Replacement (Hatchback)
Special Tools
J 21104-B
(KM 475-B) Weatherstrip Remover Universal
Removal Procedure
1.
Lower the front window.
2.
Remove the door pull screw.
3.
Remove the inside door handle.
4.
Remove the screws at the base of the trim panel.
© 2010 General Motors Corporation. All rights reserved.
http://localhost:9001/si/showDoc.do?docSyskey=2095634&pubCellSyskey=127620&pubO...
7/5/2010
Document ID: 2095634
Page 2 of 3
5.
Pry off the trim panel using the trim remover
J 21104-B
(1).
Installation Procedure
1.
Install the trim panel.
Caution:
Refer to
Fastener Caution
in the Preface section.
2.
Install the screws at the base of the trim panel and tighten to
3.5 N·m (31 lb in)
.
3.
Install the inside door handle.
http://localhost:9001/si/showDoc.do?docSyskey=2095634&pubCellSyskey=127620&pubO...
7/5/2010
Document ID: 2095634
Page 3 of 3
4.
Install the door pull screw and tighten to
3.5 N·m (31 lb in)
.
5.
Raise the window.
http://localhost:9001/si/showDoc.do?docSyskey=2095634&pubCellSyskey=127620&pubO...
7/5/2010
Document ID: 1724583
Page 1 of 2
2009 Chevrolet Aveo
|
Aveo, Wave, G3, Barina (VIN S/T) Service Manual
|
Body Hardware and Trim
|
Interior Trim and Paneling
|
Repair Instructions
|
Document ID: 1724583
Front Side Door Trim Panel Replacement (Notchback)
Removal Procedure
1.
Lower the front window.
2.
Remove the window regulator handle, if equipped.
3.
Remove the door pull screws.
4.
Using a flat-bladed tool, gently pry off the inside door pull handle cover.
5.
Pry off the trim panel.
© 2010 General Motors Corporation. All rights reserved.
http://localhost:9001/si/showDoc.do?docSyskey=1724583&pubCellSyskey=127620&pubO...
7/5/2010
Document ID: 1724583
Page 2 of 2
6.
Disconnect the necessary electrical connectors, if equipped.
Installation Procedure
1.
Connect the necessary electrical connectors, if equipped.
2.
Install the trim panel.
3.
Install the door pull screw.
4.
Install the door pull trim cover.
5.
Install the window regulator handle, if equipped.
6.
Raise the window.
http://localhost:9001/si/showDoc.do?docSyskey=1724583&pubCellSyskey=127620&pubO...
7/5/2010
Plik z chomika:
wizja11
Inne pliki z tego folderu:
body repair.pdf
(1162 KB)
Clutch.pdf
(1177 KB)
ABS.pdf
(279 KB)
Bumper and facia.pdf
(708 KB)
Engine Controls and Fuel - 1.4L (L95).pdf
(2197 KB)
Inne foldery tego chomika:
AVEO-Wave_02-06
Zgłoś jeśli
naruszono regulamin